Sunday, August 12, 2012

How to dry garlic

The one crop we've grown this year that surpassed my expectations is garlic. Garlic will last for a long time when stored in cool, dry conditions, but we have so much of it that I am worried that it will start to go bad before we use it all.  Time to find a way to preserve it before I lose it!

When I don't have garlic I grew myself (i.e. any time prior to now), I generally buy the pre-minced garlic you can find in a jar at the grocery store. Ideally, I would can all my garlic up and use it that way. You can read about how Patrice Lewis of the Rural Revolution blog cans her garlic here.

Although I am an experienced canner, I tend to follow the established guidelines and not venture into the "grey areas" of canning such as canning bacon, butter, and, as it turns out, garlic. Here is a link to an article about the safe preservation of garlic. If you read through it, you will see that they do not recommend canning garlic. It seems that pressure canning destroys much of the flavor of garlic and so canning authorities have never bothered to establish the proper processing times for garlic. That's too iffy for me and so I decided to forgo canning garlic.

With canning out, I decided to dry much of my garlic. Here's how I did it.

Drying Garlic


Peeling the garlic and trimming off the root end

I won't lie: the first step of the process is very tedious. Gather your heads of garlic and separate them into cloves. Then, peel the cloves and trim off the root ends. One reason I have mostly used pre-minced canned garlic for all these years is so I don't have to deal with the sticky, papery, garlic peels. I peeled so many heads of garlic this time that my fingers were covered with garlic juice. The peels then kept getting stuck to my fingers and transferred to the clean garlic cloves, cutting board, and pretty much everywhere else in the kitchen. It was a mess, but the good news is that the rest of the procedure is really, really easy.


I used the slicing blade on my food processor to slice the garlic into uniform pieces

Now you need to slice your garlic by hand or with a food processor. You can mince the garlic into smaller bits if you desire, but be aware that they may fall through the mesh of your dehydrator screen.


The food processor makes quick work of this task

Once your garlic is sliced, it's time to dry it. I have an Excalibur food dehydratorand I looked up the correct temperature to dry garlic in my owner's manual. I set the thermostat at 105 degrees and placed the garlic slices on the drying trays. I was worried that some of the garlic pieces were small enough to fall through the trays as they dried and shrank, so I lined the trays with plastic wrap before I put the garlic on.  I checked on the garlic every few hours and stirred it once. It took about 8 hours before it was completely crisp and dry.


The finished product

If you don't have a dehydrator, I have also read about people drying garlic in the oven. The lowest temperature my oven goes to is 170 degrees, so drying garlic in there would take careful monitoring to prevent over-browning. Ever eaten a piece of scorched garlic before? Yuck! I would turn your oven to the lowest temperature it goes, stir often, and consider propping the oven door open a bit.

What do you do with dried garlic? 

  •  Throw a few pieces into a soup or stew. It will reconstitute while it cooks and lend its flavor to the meal. You might want to fish the larger pieces out after you're done cooking the dish, though, because these babies pack quite a wallop. 
  • Grind the dried garlic in a food processor or spice grinder to make your own garlic powder.
  • My favorite: Soak a clove's worth of dried garlic in some warm water until soft. Mince and use in recipes in place of canned minced garlic!  

Enjoy! 

8 comments:

  1. A suggestion for next year's harvest:

    http://lifehacker.com/5844865/peel-a-head-of-garlic-in-less-than-10-seconds-with-two-bowls

    ReplyDelete
    Replies
    1. Interesting! I'll definitely try this out, though I have to admit it looks too good to be true!

      Delete
  2. Holy Cow - look at all those chicken eggs!!!!! How have you been using all of them??

    ReplyDelete
    Replies
    1. LOL! We've been selling them in addition to eating them about every which way you can think of. :)

      Emily

      Delete
  3. Have you fallen of the earth?

    ReplyDelete
    Replies
    1. Nope! I am just going through an exceptionally busy season with family and school obligations. I am also recovering from a very nasty bout with the flu and so I haven't been keeping up as well as I should.

      Delete
  4. Great piece on drying garlic at home. Thanks for sharing this!

    ReplyDelete
  5. Hey,
    Learn a lot from your write up. Very nice understanding with the user. I have little demand for you. Could you please share a post about best food dehydrator. I have to look for the last 2 days but didn't find a proper review about it. If you share it I appreciate it with you.
    Cheers
    Jessica

    ReplyDelete